8.2MW YQW gas-fired thermal oil heater for construction industryThermal oil heater plays an essential role in the productive progress of construction industry, providing heat energy in the process of molding, drying and embossing. Huayuan Mineral Wool Board Co., Ltd. is a group company specializing in producing new environmental friendly decorative materials. The company offers the products, including mineral wool board, gypsum board, calcium silicate board and magnesium to Europe, the United States, Africa and Middle East, etc. With the improvement of people's consciousness of environmental protection, new energy technology revolution and low carbon economy have become two global trends, the previous coal-fired thermal oil heater of the company has been unable to satisfy the requirement for changes of the times. The company planned to use natural gas as an alternative fuel, but attached special attention to the thermal efficiency of the cost of fired boiler in consideration of the higher price of natural gas. The thermal oil heater produced by ZOZEN has superior performance advantages as below: multi-loop coil tube design features safe operation and sufficient heating surface, plus the customized recovery system of waste heat, the thermal efficiency of the thermal oil heater can reach up to 95%; Meanwhile, it equips with advanced combustion apparatus for lower NOx emission (NOx≤30mg/Nm3). Huayuan Mineral Wool Board Company was deeply impressed by the high-quality products from ZOZEN, and ultimately ordered one set of 8.2MW YQW series gas-fired thermal oil heater.
gas oil fired cost of fired boiler working principle diagram
Gas oil fired boiler types
Comfortable life of people is inseparable from the northern winter heating cost of fired boiler, normal, stable heat source is vital to people's lives. But the attendant is an increasingly serious environmental pollution problems, the implementation of coal to gas policy without delay, using the gas hot water boiler is the general trend. In order to achieve green heating, the National Tourism Administration Service Center decided to phase out the existing coal-fired boilers, the introduction of clean and environmentally friendly gas hot water boiler. Fast boiler with their own strong comprehensive strength and rich experience in the heating industry cooperation gained the trust of the National Tourism Administration Service Center, and ultimately provide a vacuum hot water boiler (T6-2800 2 sets of 2.8MW by fast Boiler ).
The price of 1 ton of diesel steam cost of fired boiler how much? Diesel fuel boilers name suggests, is a diesel fuel as a boiler, in general belongs to a diesel boiler is oil-fired boiler series, you can also burn heavy oil, waste oil and other oils. Diesel boiler works mainly by the diesel burner (atomized) is injected into the combustion liner, into the flue gas back to the combustion chamber around the lower part of the smoke tube, forward to the front smoke box, smoke tube folding the upper, front to back It flows into the smoke box, through the chimney into the atmosphere. The price of diesel boilers have a lot, but the difference between what it? Here Henan party fast as a veteran enterprise for everyone under the doubts, the main part of the boiler refers to diesel burner, because they want to go with burner according to the viscosity and calorific value of burning oil, so the price difference is mainly in this, Henan side uses fast Italian imported burner compared to other conventional burner following advantages: 1, by volume petite we know the burner mounted in the side wall and the center distance ships diesel burner installation is not less than 1 1.2m ~, smaller volume so that the installation easier and faster. 2, stable performance increase wind speed exit back to improve combustion efficiency, good burner does not need to apply debugging, and some common die. 3, the combustion load bearing capability can bear the name suggests is a heavy load without damaging the load, but not always.
